The MV Maria Gloria

The Montenegro Shipping Lines Inc. (MSLI) is a Batangas-based shipping company founded by Vicente Montenegro in 1978 that plied ships between Batangas and Mindoro. During that time the routes to the current MIMAROPA were still dominated by wooden-hulled motor boats or what is called batel  in the region (lancha in other regions). Vicente Montenegro was one of the batel operators then and that was no shame. During that time there were no ROROs yet although there were already some steel-hulled cruisers. Even the Viva Shipping Lines which dominated MIMAROPA shipping later (when that was not a separate region yet) was also still in the age of the motor boats then.

Montenegro Lines started with the boat Malaya but when I came to know them in the 1990s they had three motor boats already, the Don Vicente, the Don Francisco and the Dona Matilde. They were holding then the Batangas City to the Abra de Ilog route. Abra de Ilog was the gateway then to the province of Occidental Mindoro through the Wawa port. During that time the motor boats were already finding it hard to fend off the ever-increasing ROROs of the Viva Shipping Lines. Well, even the other shipping companies in the area which had ROROs already were also finding it hard to compete with Viva Shipping Lines which they all feared.

nowell

Photo by Nowell Alcancia of PSSS.

Maybe reading the writing the writing on the wall that it is already the age of ROROs, Vicente Montenegro acquired a RORO on September 1994 which they named as the Maria Gloria and the ferry was fielded in the Batangas City-Abra de Ilog route. Initially, she was not very successful but Montenegro Lines persisted (as once there is a competitor, Viva Shipping Lines will immediately try a full-court press and they have a RORO in the Abra de Ilog route, the Viva Penafrancia 8 which came from Sweet Lines).

The Maria Gloria was the former Tenyo Maru of the of the Shimabara Tetsudo of Japan which is actually a railway company. She was built in 1967 by the Kanda Shipbuilding Co. in Kure, Japan and she possesses the permanent ID IMO Number 6726668. The lines and superstructure of the ship are what was common in that period in Japan for small ROROs.

Actually, the Maria Gloria is not a basic, short distance ferry-RORO. A half-deck for passengers was constructed here in the bridge deck, something that cannot be done for a basic, short-distance ferry-RORO. However, the poop deck was not extended. While a half-deck was added, the gross tonnage of the ship of 267 tons was less than its 356 gross register tons in Japan. The Registered Length of the ship is only 39.5 meters which is less than its 42.9 meters LOA in Japan and the Breadth shrank from 11.0 meters to 10.95 meters. Maybe this is part of the reason for the decrease in the gross tonnage.

Maria Gloria (tourist section)

Photo by Raymond Lapus of PSSS.

The Maria Gloria only has two of accommodation classes, the air-conditioned Tourist and usual open-air Economy and that is the usual for small, short-distance ferries to which she belongs. The Tourist is located in the forward section of the lower passenger deck and the Economy sections are located to the stern of that and in the bridge deck. The total passenger capacity is 413 persons and her rolling cargo capacity is some 350 lane-meters divided into three lanes.

Maria Gloria (economy section - lower deck)

Photo by Raymond Lapus of PSSS.

This RORO is equipped with two engines (the basic, short-distance ferry-RORO with one deck usually has one engine only) and her two funnels confirm that. Her two Daihatsu engines produce a total of 1,400 horsepower and the ship’s design speed is 11.5 knots. The current speed of the Maria Gloria is not far off that. As a RORO, the Maria Gloria has ramps in the bow and in the stern.

Maria Gloria (economy section 1 - upper deck)

Photo by Raymond Lapus of PSSS

From Abra de Ilog, the Maria Gloria was also assigned to the various routes of Montenegro Lines and it seems the farthest she went from their base in Batangas is her Dumaguete-Siquijor route of which she spent a long time too. But outside of Batangas, the base of Montenegro Lines, few realize she is the first-ever RORO of the company.

The Maria Gloria might be an old ship now (she is already over a half-century old) but she is still a reliable ship because her owner Montenegro Lines spends on the proper maintenance of their ships and in fact, in the company there are also other old ships which still run very well until now. MARINA, the local maritime regulatory agency, instead of threatening phase-out of old ferries should just use proper classification to weed out the unreliable and unsafe ships. Like the Maharlika ferries of before. Those were not too old but many were marked by unreliability for periods of time and even the paint job is not good. In Montenegro Lines, paint seems not to be a problem and that is also true with the Maria Gloria.

Maria Gloria (cargo deck)

Photo by Raymond Lapus of PSSS

The Maria Gloria is already sailing for 25 years (a Silver anniversary this month) now in our waters (will Montenegro Lines be giving a 25% discount aboard her for the month?). Whatever, at the rate she is going, I think the Maria Gloria still has many good years ahead of her and I am confident Montenegro Lines will make sure of that.

 

Philippine Ferries That Are Celebrating Their Golden Anniversaries In 2017

There are a few ferries in the Philippines which will be having their golden anniversaries this year because they have already reached 50 years of existence and sailing. That means these were built exactly in the year 1967 and all of these ferries are testaments to their design and engineering. It is also a testament to the Philippine side from the owners to the engineers for their loyalty and belief in their ships.

Not all of these ships are in the pink of health now, of course. In humans they might be the equivalent of our centenarians. But unlike our centenarians these are not exactly laid-up vessels and if not sailing they are being held in reserve. Some of these have hiccups at times but those episodes are not something that cannot be repaired. And unlike planes where there is always an emergency when an engine conks out, in ships even though it loses main engine power they simply become the equivalent of unpowered barges and barges sail day in and day out in all waters of the world.

Here then are our “golden” ferries this year:

Maybe we should start with the Maria Gloria of Montenegro Shipping Lines Inc. (MSLI). This is a notable ship because she was the first steel-hulled ferry of Montenegro Lines. She came to our country in 1994 when she was already 27 years old and she has been a good ship from the time she arrived and is still a very reliable ship until now. It looks like Montenegro Lines is taking care of her very well.

MV Maria Gloria (Ang barko na paborito ko!)

Maria Gloria by Raymond Lapus

The Maria Gloria is a short-distance ferry-RORO and for a long time served the Mindoro routes although at times she can also be found in the route to Siquijor. She was built as the Tenyo Maru for the Shimabara Tetsudo by Kanda Shipbuilding in Kure, Japan. She measures 42.9 meters by 11.0 meters and she has a passenger capacity of 413 persons. She is powered by twin Daihatsu engines with a total of 1,400 horsepower which is still good enough for some 10 knots today.

Another 50-year old ship in the fleet of Montenegro Lines is the ferry Maria Isabel which holds for the company their Iloilo-Cuyo-Puerto Princesa route across the wide Sulu Sea. Now if she is not a reliable ship Montenegro Lines won’t assign her to that route especially since swells can be powerful in her route when the monsoons are acting up.

8518402772_f87ba471e0_z

Maria Isabel by Carl Jakosalem

The Maria Isabel was originally the Shirakawa Maru in Japan and she was built by Taguma Zosen in Innoshima, Japan. Her external dimensions are 49.0 meters by 13.2 meters and she has a passenger capacity of 427 persons. A two-deck overnight ferry, her Gross Tonnage is rather high for her Length at 836 (this figure has no unit). She is powered by twin Hanshin engines of 1,700 horsepower and her design speed is high at 14.5 knots and maybe this was the reason she was assigned the long Sulu Sea route.

The Maria Isabel arrived in the country in 1997 when she was already 30 years old. Now who said imported surplus ferries should be no more than 20 years old? I say it depends on the condition of the ship. Maria Isabel has two sister ships in the Philippines and both are in the fleet also of Montenegro Lines. These are the Maria Erlinda and Maria Rebecca.

Another “golden” ship in the Philippines is one that has a complicated history and is a survivor. She first arrived in the country in 1982 as the first RORO ferry of Viva Shipping Lines which were formerly operators of motor boats like Montenegro Lines. The ship was 15 years old then, a relatively young age and she was named as the Viva Santo Nino.

The Viva Santo Nino was formerly the Bisan Maru of Sanyo Kisen of Japan. She was built by Kanda Shipbuilding in Kure, Japan and she measures 50.0 meters by 11.8 meters. Originally 665 GRT in Japan but here her GT was deflated. I am not sure of her original engines but later it were two Yanmar engines totaling 1,800 horsepower which was good for 13 knots.

The Viva Santo Nino sailed well for Viva Shipping Lines whose ships were rusty and lacked cleanliness but they don’t sink or conk out because tale says the Captain is under the pain of death if his ship sinks. But when the company stopped operations because of the tightness of competition in the Verde Island Passage and of some family troubles this ship was one of those which was laid up.

3723482950_fc61c388d5_o

Streamer of Joy-Ruby by Masahiro Homma

In 2003, the ship was sold to Silverio Atienza who was an operator of motor boats called batel in the area. With some modifications and repair, she became the Joy-Ruby, the first steel-hulled ferry of Silverio Atienza which later evolved into the Atienza Shipping Lines. However, once on a voyage to Puerto Princesa she developed a hull in the stern when she was already nearing the port. She continued sailing until she ended up sitting on her stern near the quay with her bow pointing to the sky.

5764897126_0c73ca1e73_b

The Joy-Ruby was subsequently salvaged and sold to Asian Marine Transport Corporation (AMTC) in 2008 where she became the Super Shuttle Ferry 15. For many years she plied the various routes of the company in the Visayas and mainly Ormoc but at times she also experienced some minor problems. This might not really be due to age but to the weakness of her company in maintaining ships. However, her Captain admitted that her engines were not that robust anymore but this is something that could be remedied by re-engining.

Another ship that was also built in 1967 was the Island Express II of Island Shipping Corporation. This ship is a short-distance ferry-cruiser that runs the Bantayan island route although not recently when Island Shipping was already able to build enough passenger-cargo LCTs and the cruisers of the company were already on the way out as cruisers can no longer compete against ROROs except in Zamboanga.

3649598263_9246bbf090_o

Island Express II by Masahiro Homma

The Island Express II was built as the Yuzuru by the Sanriku Shipbuilding & Iron Works in Shiogama, Japan. The ship’s external dimensions are 28.5 meters by 7.0 meters and she is equipped by a single Daihatsu engine of 300 horsepower which means she is a slow craft. This ship came to the Philippines in 1994 when she was already 27 years old. The Island Express II has a passenger capacity of 354 persons all in benches.

Another cruiser ship that was built in 1967 but is an overnight ferry is the Gloria Two of Gabisan Shipping which has fishing vessel origin and was just converted in Leyte. This ferry measures 46.3 meters by 7.7 meters and is now equipped by a single Isuzu Marine engine of 960 horsepower which gives her a cruising speed of 11.5 knots.

8563531617_4a901a1858_k

The Gloria Two is a very reliable ship although she suffers now in competition versus RORO ships. She has a passenger capacity of 386 and she has no other route except the route to Hilongos, Leyte. This ferry is declared to have a Gross Tonnage of 246 with a passenger capacity of 386 person in bunks.

There is another highly-recognizable ship that is well-known in Cebu which is the Lapu-lapu Ferry 1 of Lapu-lapu Shipping. This ship was built by Okayama Shipyard in Hinase, Japan in 1967 and she came to Sweet Lines of the Philippines in 1978. In Sweet Lines she was known as the second Sweet Time doing the Cebu-Tagbilaran-Cagayan de Oro and Cebu-Tagbilaran-Larena-Plaridel routes. Her IMO Number is 7315753.

Sweet Time

Sweet Time by Edison Sy

When Sweet Lines collapsed in 1994, she was laid up for a while until she became the Carmelita. Then she came to Lapu-lapu Shipping which renovated her extensively in 2002 in Villono shipyard until she no longer looked like the old Sweet Time, the reason why people can’t connect her to her origin. But IMO Numbers don’t lie and she was traced.

23558034950_701a9b42c4_z

Lapu-lapu Ferry 1 by Mike Baylon

As Lapu-lapu Ferry 1 her dimensions are 52.2 meters by 8.0 meters by 4.1 meters and she is an overnight ferry-cruiser. Her passenger capacity is 509 and her primary route is Cebu to Cataingan, Masbate. She still has her original Hanshin engine with 1,100 horsepower which is now just good for 8 to 9 knots. To keep up with competition, the ship has an air-conditioned Tourist section.

Another ship built in 1967 is an LCT of E.B. Aznar Shipping of
Danao, the LCT Melrivic 1 which at one time was rumored to be gone but actually was  just hiding in Republic Drydock in Danao City and being re-engined prior to re-fielding. A PSSS (Philippine Ship Spotters Society) tour group found her being refitted in that shipyard. This passenger-cargo LCT is a local-build in Manila.

10959653994_41b602d5f9_k

LCT Melrivic 1 by John Carlos Cabanillas

This vessel’s measurements are 37.4 meters by 8.0 meters which means she is a small LCT and her Gross Tonnage is 321. Originally powered by a single Yanmar Marine engine of 430 horsepower, she is now powered by a Weichai engine of 460 horsepower and her speed increased from 9.5 knots to 11 knots while being more fuel-efficient.

The next ship which is 50 years old now is a respected ship in Bicol but she was not originally a Bicol ferry. In Japan she was known as the Nangokutosa Maru of the Utaka Kokudo Ferry and she was built by Hashihama Zosen in Imabari, Japan. The ship measures 64.0 meters by 11.3 meters with an original Gross Register Tonnage of 904 tons and equipped with twin Daihatsu engines with a total of 2,200 horsepower.

4644972151_94f4f57627_b

Princess of Mayon (parsed from a PPA photo)

In 1990, this ship came to United Towage & Salvage of the Philippines when she was already 23 years old. In this company she was known as Horizon but United Towage & Salvage was actually not into passenger shipping. The ship underwent modifications and she was sold to Bicolandia Shipping Lines where she became known as the Princess of Mayon. For a very long time as in two decades, she was the biggest ferry in Bicol and she was always in the strongest route there, the Matnog to Samar route.

When Bicolandia Shipping Lines was sold lock, stock and barrel to Penafrancia Shipping Lines in 2006, the Princess of Mayon became part of the deal and in the new company she was known as the Don Benito Ambrosio II. She had periods of unreliability soon after. The company’s solution was to build one reliable Daihatsu engine from her two Daihatsu engines and a Yanmar engine was mounted as the second engine.

33156335581_7eefa590cd_k

Now Don Benito Ambrosio II is running well again and she is still in the same route again. The PSSS (Philippine Ship Spotters Society) touring group was able to ride her free last December, “Bridge Class” and know what? Her bridge is air-conditioned! Now, tell me, how many short-distance ferries locally can claim that kind of accoutrement?

The last two vessels that were built in 1967 are both local-builds. Both are small because they were ferries of their companies when they was still young. These two are obsolete now being slow, small cruisers and most of the time they no longer sail. The two are the Ever Transport of Ever Lines and the Magnolia of Magnolia Shipping Corporation, both of Zamboanga City.

8176937651_dc62cc28b9_h

The Ever Transport was built in Cebu and just measures 19.2 meters by 5.1 meters with a Gross Tonnage of just 68 and a passenger capacity of just 87 persons. Her engine is an Isuzu diesel of just 135 horsepower but she can reach 7.5 knots when she was still new. I thought then she was already gone and then I saw her being refitted in Varadero de Cawit in Zamboanga City and they said she will sail again.

Meanwhile, the Magnolia was built by Rato Brothers in Pagadian, Zamboanga del Sur. Her external dimensions are 26.6 meters by 5.4 meters with a Gross Tonnage of 81 and a passenger capacity of 122 persons. The upper half of her hull is wood and the lower half is steel. The Magnolia is powered by a single Caterpillar engine of 120 horsepower. The last time I saw her was she was laid up in Varadero de Recodo in Zamboanga City.

Both the Ever Transport and Magnolia are clearly obsolete now. In passenger capacity they are not even higher than the big passenger-cargo motor bancas which have the same horsepower as them or even more. However, the two can carry more cargo especially since they have high prows and freeboards so they can deal with the sometimes big swells of the seas near Zamboanga.

6449489737_8b5fd169a9_b

Magnolia by Mike Baylon

So that’s it, folks. A total of eight ferries that will be celebrating their 50 years now. Some are already obsolete especially the cruisers because as they say times and modalities change but they are still alive. Do I hear the tune of the BeeGees, “Stayin’ Alive”?

Not all the ferries mentioned have IMO Numbers and some were not traced initially but the cooperation with Angelo Blasutta of the former Grosstonnage.com bore fruit and so the Don Benito Ambrosio II and Lapu-lapu Ferry 1’s origins were traced and both were actually clear surprises.

I always joke that ferries 50 years old should give a discount of 50%, a celebration for being still alive. Oh, it can be not the whole year. Maybe on the month that they were built, at least. And the crew might even be surprised because I found out over the years that many crewmen cannot trace the history of their vessels because they were not trained to look for the IMO Number.

On a future article I will deal with our our ferries built in 1967 that are no longer around and what has happened to them so the people including the haters of old ships will be more educated.

The MV Maria Gloria

When Montenegro Shipping Lines Inc. (MSLI) started they were not operators of RORO ships. Instead they were operators of wooden motor boats which were called batel in the Southern Tagalog area. Their batel fleet then consisted of the MB Don Vicente, the MB Don Francisco and the MB Dona Matilde. The first might have been named for the patriarch and founder Vicente Montenegro. The Montenegro Lines batels were dedicated Batangas-Abra de Ilog ships which means that was their only route. However, normally only two of the three will be sailing the route on any given day. Abra de Ilog is the main entry in the north of the province of Occidental Mindoro up to now because it is the nearest to Batangas City, the gateway to the island of Mindoro.

Suddenly, on September 1994, a RORO ship arrived for Montenegro Lines without notice. This was the MV Maria Gloria, the first ever RORO (Roll-On, Roll Off) ship for Montenegro Lines. The ship was also fielded in the Batangas-Abra de Ilog route and at first it competed with their own batels which means one of them has to give up its schedule for MV Maria Gloria. When that ship arrived it was still the time of the complete dominance in Southern Tagalog of Viva Shipping Lines and its legal fiction companies and they were very jealous of any newcomer including in scheduling. This company used to bully their competition and underhanded tactics are routinely ascribed to them. In fact, they are simply feared and many of their wannabe competitors got bankrupted. So when MV Maria Gloria arrived and she was a RORO, the field Viva Shipping Line is very jealous of, there were questions in Batangas how long she would last.

Well, MV Maria Gloria lasted and in 1996, Montenegro Lines added another ship, the MV Marie Kristina, a small, basic short-distance ferry RORO. In 1997 Montenegro Lines added the MV Maria Angela, the MV Maria Isabel and the MV Marie Teresa. From then on Montenegro Lines was adding ships every year and their route system grew. In 2002, it was the turn of Viva Shipping Lines and cohorts to become bankrupt and they quit sailing routes one by one. Montenegro Lines grew to become the country’s shipping line with the most number of passenger ROROs (albeit they were generally small and mainly running short-distance routes).

MV Maria Gloria is not a short, basic short-distance ferry-RORO. She is a tad bigger at 42.9 meters by 11.0 meters. One characteristic of this type of RORO is they have their bridge or pilot house on a deck above the passenger deck whereas small, basic short-distance ferry-ROROs have their bridge on the same level as the lone passenger deck. MV Maria Gloria has scantling behind her bridge which serves as a short but another passenger deck. And unlike the small, basic short-distance ferry-ROROs which a lone RORO ramp at the bow, she has RORO ramps at the bow and at the stern. Another difference with the small, basic short-distance ferry-ROROs which have only one engine and one propeller, this type have two engines and two propellers (and also two funnels). She also have that square box at the bow which limits the ingress of rain water in the car deck which makes it slippery. It is also a protection against rogue waves coming at the front.

The MV Maria Gloria started as the MV Tenyo Maru in Japan of the Shimabara Tetsudo (“tetsudo” translates to “railway”) and might have been used in the Shimabara Peninsula east of Nagasaki, Japan. This ferry was built by Kanda Shipbuilding Co. in their Kure yard in Japan in 1967 (so she is just short of one year before she turns “golden” or 50). A steel-hulled ship, she has only one mast with a raked stem and a transom stern. She has three RORO lanes in her car deck with an approximate length of 40 meters. The ship has about 400 lane-meters of rolling cargo space. That will be good for about six long trucks and buses at the sides if there is no obstruction and about eight or nine sedans in the middle. However, in loading, seldom is there an ideal combination of rolling cargo load.

The MV Maria Gloria is a two-class accommodation ship with an airconditioned Tourist accommodation at the front of the middle deck with benches. The rest of the passenger accommodations is open-air Economy. All the accommodations are just sitting as the MV Maria Gloria is just used on short-distance routes connecting the near islands. The total passenger capacity of the ship is 413 persons. Her original Gross Register Tonnage (GRT) in Japan was 356 tons but her Gross Tonnage (GT) went down to 267 in the Philippines even though scantlings at the bridge deck were added. The Net Tonnage (NT) is 104 locally and her loading capacity is 140 tons in Deadweight Tonnage (DWT). The ship’s Depth is 2.5 meters which is really not deep.

The MV Maria Gloria is equipped with two 6-cylinder Daihatsu marine diesels with a total of 1,400 horsepower which gives her a top speed of 11.5 knots. She has a normal complement of 24 and her local Call Sign is DUE 2090. Internationally, her permanent ID is IMO 6726668. Originally, in 1994, the ship’s registered owner was Jovanlyn Trading and General Merchandise, an outfit I have not heard of and she was the only ship of that unknown company. In 2000, her ownership was transferred to Montenegro Shipping Lines, Inc. (MSLI). Maybe at the start she was made to look as if she was only chartered.

Montenegro Lines has the long-time custom of rotating their ship assignments every few months or so. And so like here fleet mates, MV Maria Gloria has already been around, so to say, which means she has already run the gamut of the so-many routes of Montenegro Lines. The only routes she has not been to are the eastern seaboard routes of Montenegro Lines and their Iloilo-Palawan route. Most of the time she held Mindoro routes including her original Batangas-Abra de Ilog route. Lately, she is based in Dumaguete port and she is doing the Siquijor route for the company.

From what I heard, Montenegro Lines takes care well of this ship. That is a normal custom for first ships of a company. Of course, there is no connotation here that she is the “flagship” of the company.

With the easiness to change hull plates now and to acquire replacement engine room and bridge machinery, she seems to be destined for a lot more of life. That is also true for the main engine which can easily be replaced now even with brand-new ones like what were done for several ships of the Montenegro Lines fleet. It is really much easier to preserve an old ship now that to acquire an expensive brand-new one. So it seems the “related” Montenegro Lines and Starlite Ferries Inc. have different approaches.

A dozen years from now I expect MV Gloria will still be easily around and sailing. Montenegro Lines is one of the best locally in preserving old ships and it is not their wont to be included in the list of maritime hull losses (they only have one there in the last 22 years).

Long live the MV Maria Gloria!

[Photo Owner: Ramiro Jr. Aranda]