The MV Asia Japan, the third to carry such name in the Trans-Asia Shipping Line, Incorporated (TASLI) fleet is the Asia Japan most would likely remember. But she was already the third to carry such name in the Trans-Asia fleet as two previous cruiser ships named Asia Japan came before her in the Trans-Asia fleet Shipping Line. The third Asia Japan I am describing here is a RORO (Roll-on, Roll-off) ship and not a cruiser ship like the first two to carry that name. Her company, the Trans-Asia Shipping Line, Incorporated is a regional shipping company based in Cebu that is sailing Visayas-Mindanao routes.
The first Asia Japan was the former Ishu Maru from Kyushu Yusen of Japan with the IMO Number 5164459. She was built in 1957 and she came to the Trans-Asia Shipping fleet in 1975. This ship was later sold to Roble Shipping Incorporated where she became the second Guada Cristy of that company. The second Asia Japan, meanwhile, was the former Nankai Maru from Nankai Kisen of Japan with the IMO Number 7130191. She was built in 1956 and she came to the Trans-Asia Shipping fleet in 1974 where she was first known as the Solar before she became the second Asia Japan (Trans-Asia Shipping Line Incorporated was first known as Solar Shipping Line Incorporated). This ship was later sold also to Roble Shipping Incorporated where she became the first Guada Cristy. She was wrecked in 1990, the reason why there became a second Guada Cristy.
The second Asia Japan was sold by Trans-Asia Shipping Line Incorporated in 1988 when the third Asia Japan was purchased by the company from Ise Bay Ferry or Ise-wan Ferry. This Japanese company sold this ship, their Atsumi Maru because their brand-new Atsumi Maru was already delivered to them. Incidentally, this successor Atsumi Maru also came to the Philippines in 2007 to the fleet of Montenegro Shipping Lines Incorporated (MSLI) where she is known as the Maria Oliva.
The earlier Atsumi Maru was built by Naikai Zosen Taguma Works in Taguma, Innoshima, Japan in 1973. She is steel-hulled ship with a raked stem and a transom stern, two masts and a single passenger deck. A RORO ship, she has a bow ramp and a stern ramp and a single car deck. She has an over-all length of 64.0 meters, a length between perpendiculars of 60.3 meters and a maximum breadth of 13.1 meters. Her original Gross Register Tons (GRT) was 990 and her Deadweight Tonnage (DWT)was 403 tons. She is equipped with 2 x 2,000hp Daihatsu engines which propelled her to 16 knots on two screws. In the Philippines, her probable sister ships are the late Starlite Voyager of Starlite Ferries Incorporated (though their bows are different) and the Reina Timotea of Marina Ferries, the legal-fiction sister company of Montenegro Shipping Lines Incorporated.
When Atsumi Maru arrived in the Philippines in 1988 to become the third Asia Japan, another deck was added to her to increase the passenger capacity. She was also converted into an overnight ferry with bunks. With that, her Gross Tonnage rose to 1,302 with a Net Tonnage of 359 and her Deadweight Tonnage also increased to 443 tons. Her new passenger capacity was 454 persons in a three-class configuration – Cabin, Tourist and open-air Economy. She had a good restaurant, a bar-lounge, a lobby and a front desk. This Asia Japan already had a Hotel Department aside from the Deck Department and Engine Department, one of the first regional ships to have such distinction. Maybe that has a connection to its first route Zamboanga which I will discuss later. For easier docking this ship is also already equipped with side thrusters at the bow. She also had a cargo ramp at the port side and two passenger ramps at the stern and another ramp at the port side.
Her first route was the Cebu-Dumaguete-Dipolog-Zamboanga route. This was still the time when big Cebu regional shipping companies Trans-Asia Shipping Lines, George & Peter Lines and the Zamboanga-based Aleson Shipping Lines were still giving much importance to the Cebu-Zamboanga connection via Dumaguete (this was later downgraded by the opening of the Dapitan-Dumaguete RORO connection). It was amazing then that a new ship like the third Asia Japan will be fielded to this route when Trans-Asia Shipping Lines was still using their older overnight ferry-cruisers in the Cebu-Cagayan de Oro route which was the premier Visayas-Mindanao route.
Later, the third Asia Japan was also fielded in the Cebu-Cagayan de Oro route when Trans-Asia Shipping Lines began selling their old overnight cruisers in the early 1990’s. But with the arrival of the new and bigger RORO series of Trans-Asia Shipping Lines – the Trans-Asia (1) in 1993, the Asia Philippines in 1994 and the Asia China in 1995, Asia Japan was relegated to the secondary routes of the company like Cebu-Iloilo. Very soon the Visayas-Mindanao overnight ferry wars which was started with the creation of the big Cebu Ferries Company started and Trans-Asia Shipping Lines had to reserve her best and biggest ferries to the Cebu-Cagayan de Oro premier route. This was also marked by the withdrawal of Trans-Asia Shipping Lines in the Cebu-Zamboanga route and just sticking to cargo there with the Asia Pacific. The coming of the more superior Lady Mary Joy (1) of Aleson Shipping Lines practically closed the door to them in Zamboanga (this Aleson ship is different from the current Lady Mary Joy 1 of the company). Trans-Asia Shipping Lines was immediately under siege by the much bigger Cebu Ferries Corporation as they bore the brunt of the offensive of that subsidiary of the giant William, Gothong & Aboitiz (WG&A) shipping line.
The third Asia Japan sailed many secondary routes for Trans-Asia Shipping Lines. Before the end of the old millennium the assignments of the fleet got quaky with the losses of the Asia South Korea (grounding and sinking) and Asia Thailand (fire) with no clear replacement. Not long after, this the RORO Asia Singapore, the Second, was also sold to F.J. Palacio Lines. Later, the third Asia Japan was assigned to the Cebu-Masbate route of the company. She was a big success there as that route of Trans-Asia Shipping Lines was practically a monopoly. And Masbatenos were not disappointed at her appointments especially since she was a former Cebu-Zamboanga ferry, a route which takes about a day with its two stop-overs. In routes such as this, the passengers’ comfort and sustenance needs are greater than that of a simple overnight ferry.
Once, I booked a ticket from Cebu to Cagayan de Oro hoping to catch either the Trans-Asia (1) or Asia China. Lo and behold, when I reached the waterfront what I saw waiting for us was the Asia Japan. I actually grumbled and said we are entitled to a discount as our fare was supposedly on that superior-than-her sister ships. I can accept the third Asia Japan as a Cebu-Masbate ferry as there was none better than her in that route (her reliever Asia Brunei was just as good) but the Cebu-Cagayan route is littered with superior overnight ferries that was at or near the level of Manila liners like the Princess of the Ocean, the Our Lady of Good Voyage, the Our Lady of the Rule and the Dona Rita Sr.
I was disappointed. The aircon was not strong and the restaurant was no longer as good as before. Maybe her best Hotel Department crewmen were already assigned to the better overnight ferries of Trans-Asia Shipping Lines. And then I was furious that when I woke up we were still just at the entrance of Macalajar Bay and still distant from Cagayan de Oro. Other passengers were already impatient and I even saw one flash the pumping arm sign to the bridge which is a universal sign of “Hurry up!”. Passengers in this route were used to daybreak or even dawn arrivals which were needed by passengers still travelling 300 land kilometers or over by buses or commuter vans like me.
Soon, some were groaning they were already hungry. I was, too. I know that by MARINA rules they should have fed us breakfast but there was no decent breakfast to speak of even if one was willing to pay. It was a personal disaster to me as I was a diabetic. We finally reached Cagayan de Oro port and to a man I know all were disappointed. They should never have substituted Asia Japan in that route because it will just be a disaster for the goodwill and reputation of the company like what happened. I asked of the speed and a crewman grimly admitted she can just do 10 knots then, best. Use that in a 134-nautical mile route with a departure of 8PM and no breakfast; it does not need coconuts to foresee the consequences. I thought they should just better stick Asia Japan to the 110-nautical mile Cebu-Masbate route where the expectations of the passengers is not so high. In an afterthought, yes, I also realized she has been sailing for nearly nearly twenty years already and it seems time has not been very kind to her engines.
Not very long after that Asia Japan was seen by members of the Philippine Ship Spotters Society (PSSS) to be just laid up in the Ouano wharf in Mandaue, tied up. It was intriguing the members especially since the fleet of Trans-Asia Shipping Lines was very thin for its routes. Already gone were the Asia Brunei, Asia Hongkong which were both sold and soon Asia Malaysia was gone, too (she capsized and sank off Iloilo). And there was the third Asia Japan just lying around there. That time, Trans-Asia Shipping Lines cannot even serve her Nasipit route and just a single ship from two was serving her Iloilo route.
Once, on a visit to Ouano wharf, we were able to ask the in-charge of the ship her state. He told us third Asia Japan was sold by Trans-Asia Shipping Line to Key West Shipping Line Corporation which were operators of tugboats and partner then in the West Ocean Lines & Transport Incorporated operating container ships. We saw some works being done and the in-charge told us the ship will be used for a Cebu-Zamboanga run. That was intriguing as she was a former Cebu-Zamboanga ship and neither Key West Shipping Line Corporation nor West Ocean Lines & Transport Incorporated have operated ferries before. I am not even sure if they were holders of a franchise (CPC) in that route but in case it will be a welcome development since there was just one ferry left in the Cebu-Zamboanga route, the Zamboanga Ferry of George & Peter Lines and she was already very slow then.
Soon the little works we observed in Ouano wharf stopped and the next thing we knew was she was already in Nagasaka Shipyard in the shipyard row of Cebu in Tayud by the Cansaga Bay and bridge. We thought then further works will done there especially since the in-charge in Ouano admitted to us that the third Asia Japan doesn’t have strong engines anymore. Then me and a fellow ship spotter were able to board the ship and meet her new officer-in-charge, Engr. Rey Bobiles, the naval architect of Sta. Clara Shipping Corporation, a Bicol shipping company. It was a surprise and a further intrigue!
Yes, the third Asia Japan was renamed into Strong Heart 1, a show she was really transferred to the Key West Shipping Line Corporation as all the names of the vessels of the company starts with “Strong” like Strong Will, Strong Devotion, Strong Desire, Strong Dignity, Strong Bliss, etc. No, she will no longer be sailing for Zamboanga as she has already been sold to Sta. Clara Shipping Corporation and will become a Bicol ferry. It turned out that Trans-Asia Shipping Line sold her to Key West Shipping Line Corporation to settle fuel debts dacion en pago. I suddenly realized the connection. Trans-Asia Shipping Line was also intending to sell Trans-Asia 3 because “she consumes too much fuel”. It seemed believable at first glance because she has 2 x 4,500 horsepower engines. Then an investigation with the proper authorities commenced and it turned out Trans-Asia Shipping Line was simply a victim of a fuel scam as in fuel pilferage, a scourge of our local transport fleet. It happens even in the tankers, in the fishing fleets, in land tankers and in trucks.
Strong Heart 1 stayed very long in Nagasaka Shipyard with few works being done. She simply became the office of Sta. Clara Shipping Corporation and clearing house for the new crew recruits of the company and dormitory at the same time. She can stay in the shipyard long because Sta. Clara Shipping Company and her sister company Penafrancia Shipping Corporation are stockholders in Nagasaka Shipyard. Actually, vessels of the companies were withdrawn from the servicing of Mayon Docks Incorporated in Tabaco City in Albay and transferred to the care of Nagasaka Shipyard. Bicol ships also owned by the related stockholders of the two companies were also being transferred to the care of Nagasaka Shipyard. Nagasaka Shipyard was the former Villono Shipyard before the change in the ownership structure (Engr. David Villono, the founder is still the head of this shipyard).
While in the shipyard engine parts were ordered fabricated in Japan. When that arrived in 2014, serious restoration work was done on Strong Heart 1 which was already renamed to Nathan Matthew. Since she has lain untended in sea water for several years she was already rusty and when walking around one has to be careful not to fall in the weak deck plates and stairs. It was even raining at times inside some portions of her already. So, she was stripped to metal by sandblasting, her weak hull and deck plates were replaced and her engines were repaired.
A portion of her superstructure in the aft of the second deck was removed too since it was thought her space for passengers as a short-distance ferry will be enough since she will simply be fitted with sitting accommodations. With this, her gross tonnage was reduced to 1,030 nominal tons and her net tonnage was also reduced to 357 nominal tons. Her passenger capacity increased to about 800, however. So the rumor and the wish that she will still be an overnight ferry in the Liloan-Lipata route never materialized. Drivers and passengers in that route wished there will be a replacement of the Ocean King I in that route since when they arrive from Manila or Luzon they are already badly in need of an accommodation where they can lie down and sleep.
Upon finishing works in Nagasaka, the Nathan Matthew was first fielded in the Masbate-Pio Duran, Albay route. I don’t know if they want to tickle the Masbatenos but for sure many there will be many there who will recognize her even if she was already converted to a short-distance ferry, even though the bow ramp has changed and even though they chopped off part of the second passenger deck and even though the name has changed. Even with alterations, I noticed passengers really familiar with a ship still recognize them even after a long absence. Nathan Matthew won’t be an exemption.
She did not stay long there in that route, however. In not a long time she was transferred to the new Liloan, Southern Leyte to Lipata, Surigao route of Sta. Clara Shipping Corporation. The company has long been a holder of a franchise (formally Certificate of Public Convenience) in that route but it is only now that they had a ship that can serve there. Right now, Nathan Matthew is the biggest ship in that route especially since the Archipelago Ferries Philippines Corporation ships (the Maharlika Dos, Maharlika Cuatro and Maharlika Cinco) are already gone in that route.
There, Nathan Matthew is directly competing with the newly-fielded FastCats of Archipelago Philippine Ferries, the obsolescent Millennium Uno of Millennium Shipping and the Cargo RORO LCTs chartered by NN+ATS which is aimed against the truck congestion in that route (also for really heavy load like earth movers and trailers capable of carrying that). However, that route is slowly being squeezed by the shorter Benit, San Ricardo to Lipata route held by Montenegro Shipping Lines Incorporated (MSLI). Now it seems a new port will be built in San Ricardo, S. Leyte and if that will materialize that might be the end of the Liloan-Lipata route.
In won’t mean the end of Nathan Matthew, however, as she might simply be transferred to the new San Ricardo route. Otherwise, she can also be fielded in the other routes of owner Sta. Clara Shipping Corporation (making her more well-travelled). It won’t be much of a burden for them because her owners are known also for having deep pockets, relative by Bicol standards. They are even operating their own port now in Allen, Northern Samar.
Sta. Clara Shipping Corporation is known for taking care well of old ships. They are actually allergic to breakers, to put it in another way. And with the support of Nagasaka Shipyard, this refurbished ship looks like it still has a long way to go. With the Sta. Clara Shipping Corporation officers and crew steeped and trained in the dangerous swells of San Bernardino Strait I don’t see her suffering the fate of the capsized and sank Maharlika Dos in Surigao Strait, knock on wood.
Long live then this well-travelled ship!